News happening around Little Rock Air Force Base

News

Base's oldest aircraft are GONE!

LITTLE ROCK AIR FORCE BASE, Ark. -- Editors note: This is part one of a three part series.

A war hero, credited with saving the lives of Little Rock Airmen overseas in Somalia over a decade ago, was retired after 34 years of service here recently.

Aircraft 37-888, a C-130E, made its final journey off the Little Rock AFB flightline on its way to Davis-Monthan AFB, Ariz. to be placed into "temporary, mothballed" status at the Aerospace Maintenance and Regeneration Center.

Aircraft 37-888 is one of 14 aircraft assigned to the base that were given the designation of "XJR," otherwise known as grounded and non-mission capable because they've exceeded their design lifespan due to Center Wing Box cracks, according to Chief Master Sgt. Bill Goodwin, 314th Aircraft Maintenance Squadron superintendent.

Recent legislation, the National Defense Authorization Act of 2007, allowed Air Force officials to place older Air Force aircraft into mothballed status including 51 C-130Es; however the law stated the aircraft must be 'in a condition that would allow recall of that aircraft to future service."

A viscious cycle on maintainers

These aircraft were grounded from one to three years, and cost the Air Force thousands of dollars a month to maintain.

"The aircraft were a drain on resources and manpower," said Maj. Andrew Phillips, 314th Aircraft Maintenance Squadron operations officer. "We didn't earn additional manpower--but we had to keep them flyable."

The aircraft ages vary from 30-40 years old, but one thing they all have in common is extremely high flight hours and problems with their Center Wing Boxes--the part of the aircraft that keeps the wings fixed onto the fuselage of the aircraft.

Currently, aircraft are placed into restricted status at 38,000 flight hours and are grounded at 45,000 flight hours. But, one flight hour in the air may actually equal many more than that as determined by crew calculations that factor in multiple variables to include turbulence, cargo capacity and the environment.

"There's huge wear and tear on a Herk," Major Phillips said. "Five flight hours may actually end up eating away 10-15 hours in reality."

The departure

After a "confidence flight" by a Functional Check Flightcrew the Herk was deemed well enough to fly to the Southwestern corner of the U.S.

The aircraft are placed into "mothballed" status because "they could possible get a new wingbox" and return to flying, said Chief Goodwin. And that possibility of returning a 40-year-old airplane to service isn't as far-fetched as it may seem.

Aircraft 67-1855 just returned here in 2005 from the AMARC with a new center wing box, according to Chief Goodwin.

The cost-analysis between flight hours and repairing or replacing the center wing box may not be effective. Currently, a new wing box costs about one year of labor-time and $10 million, whereas the purchase of a new C-130J costs about $66 million--and a new aircraft is in the air.

Mothballing an aircraft is not easy and brings "unique challenges," Major Phillips said.

The aircraft may have been sitting for years, now it's being put through the paces to fly. Airmen are taking fuel samples, bringing up and checking hydraulic pressure and ensuring flight controls work properly.

The 314th Airlift Wing had 10 grounded aircraft, nine here and one at a depot awaiting transfer to the AMARC. The 463rd Airlift Group had four here awaiting transfer.

The aircraft

Aircraft 37-888 is not new to being in the limelight. It's last major 15 minutes of fame were when it was televised internationally on CNN from Africa where it was used in action in Somalia.

"Eight-eight is a war veteran," Major Phillips said jokingly.

"It took fire," Chief Goodwin said reflecting on his time in the 50th Airlift Squadron which was engaged in Somalia at the time. "I remembered everyone worrying about us when they saw it on TV. Fortunately it took care of us."

The Herk is the workhorse of war and the Air Force depends on them heavily, according to Col. John Gomez, 463rd Airlift Group commander. Recently the 61st Airlift Squadron just returned an E model to Balad AB, Iraq to continue carrying passengers and cargo for theater operations, he said.

"The C-130E is needed in theater," Colonel Gomez said. "If you give us 10 more, or 50 more, we'll use them."

According to Central Command, C-130 and C-17s accounted for carrying 720,000 pounds of cargo on 130 sorties and moved more than 2,600 passengers.

The Air Force Fleet Viability Board visited the base Dec. 7 in order to determine the future of the C-130 fleet.

The new home

The AMARC, also referred to as the "Boneyard," is home to many military aircraft that have surpassed their serviceable lifespan and "provides critical aerospace maintenance and regeneration capabilities for Joint and Allied/Coalition warfighters in support of global operations and agile combat support for a wide range of military operations," according to the unit's fact sheet.

The AMARC is aligned under Air Force Materiel Command and is home to many airlift, bomber, fighter and reconnaissance aircraft.
USAF Comments Policy
If you wish to comment, use the text box below. AF reserves the right to modify this policy at any time.

This is a moderated forum. That means all comments will be reviewed before posting. In addition, we expect that participants will treat each other, as well as our agency and our employees, with respect. We will not post comments that contain abusive or vulgar language, spam, hate speech, personal attacks, violate EEO policy, are offensive to other or similar content. We will not post comments that are spam, are clearly "off topic", promote services or products, infringe copyright protected material, or contain any links that don't contribute to the discussion. Comments that make unsupported accusations will also not be posted. The AF and the AF alone will make a determination as to which comments will be posted. Any references to commercial entities, products, services, or other non-governmental organizations or individuals that remain on the site are provided solely for the information of individuals using this page. These references are not intended to reflect the opinion of the AF, DoD, the United States, or its officers or employees concerning the significance, priority, or importance to be given the referenced entity, product, service, or organization. Such references are not an official or personal endorsement of any product, person, or service, and may not be quoted or reproduced for the purpose of stating or implying AF endorsement or approval of any product, person, or service.

Any comments that report criminal activity including: suicidal behaviour or sexual assault will be reported to appropriate authorities including OSI. This forum is not:

  • This forum is not to be used to report criminal activity. If you have information for law enforcement, please contact OSI or your local police agency.
  • Do not submit unsolicited proposals, or other business ideas or inquiries to this forum. This site is not to be used for contracting or commercial business.
  • This forum may not be used for the submission of any claim, demand, informal or formal complaint, or any other form of legal and/or administrative notice or process, or for the exhaustion of any legal and/or administrative remedy.

AF does not guarantee or warrant that any information posted by individuals on this forum is correct, and disclaims any liability for any loss or damage resulting from reliance on any such information. AF may not be able to verify, does not warrant or guarantee, and assumes no liability for anything posted on this website by any other person. AF does not endorse, support or otherwise promote any private or commercial entity or the information, products or services contained on those websites that may be reached through links on our website.

Members of the media are asked to send questions to the public affairs through their normal channels and to refrain from submitting questions here as comments. Reporter questions will not be posted. We recognize that the Web is a 24/7 medium, and your comments are welcome at any time. However, given the need to manage federal resources, moderating and posting of comments will occur during regular business hours Monday through Friday. Comments submitted after hours or on weekends will be read and posted as early as possible; in most cases, this means the next business day.

For the benefit of robust discussion, we ask that comments remain "on-topic." This means that comments will be posted only as it relates to the topic that is being discussed within the blog post. The views expressed on the site by non-federal commentators do not necessarily reflect the official views of the AF or the Federal Government.

To protect your own privacy and the privacy of others, please do not include personally identifiable information, such as name, Social Security number, DoD ID number, OSI Case number, phone numbers or email addresses in the body of your comment. If you do voluntarily include personally identifiable information in your comment, such as your name, that comment may or may not be posted on the page. If your comment is posted, your name will not be redacted or removed. In no circumstances will comments be posted that contain Social Security numbers, DoD ID numbers, OSI case numbers, addresses, email address or phone numbers. The default for the posting of comments is "anonymous", but if you opt not to, any information, including your login name, may be displayed on our site.

Thank you for taking the time to read this comment policy. We encourage your participation in our discussion and look forward to an active exchange of ideas.

Photo Gallery: Week in Review

News Search